Physics Grade 12 Pdf | Turbo

But his measured 135°C meant . The compressor efficiency (η_c) = (T₂_ideal – T₁)/(T₂_actual – T₁) = (78-25)/(135-25) = 53/110 ≈ 48%. The rest of the work became heat due to friction and turbulence. Chapter 4: The Density Battle Kael connected the compressor outlet to a small engine cylinder. More air pressure meant more oxygen molecules per volume—but the heat reduced density. Using the ideal gas law rearranged: ρ = P / (R_specific × T)

“More air means more fuel can be burned,” Kael said. “That’s the power gain.” But 135°C air caused engine knock. Dr. Vane handed him an intercooler—an air-to-air radiator. After the intercooler, temperature dropped to 45°C while pressure only dropped to 1.7 atm.

T₂ = 298 K × (1.8/1.0)^0.286 T₂ = 298 × 1.8^0.286 1.8^0.286 ≈ 1.178 T₂ ≈ 351 K → 78°C (theoretical ideal). turbo physics grade 12 pdf

Density ratio vs. ambient: 1.89/1.18 = 1.60 → 60% more air.

To reduce lag, Kael lightened the turbine wheel (lower I) and designed a smaller A/R (area/radius) turbine housing—which increased exhaust velocity but reduced top-end flow. At full throttle, boost climbed past 2.2 atm. The engine detonated. Dr. Vane pointed to a small actuator: the wastegate. It diverted exhaust around the turbine when boost exceeded a setpoint. But his measured 135°C meant

At steady state, Power_turbine × η_mech = Power_compressor

“Cooling after compression is like cheating physics,” Kael grinned. “You increase density without losing the work already put in.” The turbo didn’t work instantly. At low RPM, exhaust flow was weak. Kael plotted mass flow rate vs. pressure ratio on a compressor map. The surge line showed where airflow reversed—flutter. The choke line where flow stalled. Chapter 4: The Density Battle Kael connected the

Kael disassembled the twin volutes: the turbine housing (hot side) and compressor housing (cold side). Inside, he found two wheels connected by a common shaft. He knew the basics—exhaust gases spin the turbine, which spins the compressor, which shoves more air into the engine—but why did that make power?